Re: [diesel_mercedes] 240D Update

 

At least now you know what to look for in the next car.

Carl


On 2/29/2012 9:56 PM, Kevin Kraly wrote:

 

I found some things that were better than expected, and a couple things that were a bit worse. The sway bar link isn't broken. The dragging sound was the exhaust pipe rubbing on the axle. As a temporary repair, I replaced the missing donut with a couple zip ties until I get the parts. The bad part was when I jacked up the left front to switch out the badly worn tire with the much better spare. This was when I found a bit of rot under the jack point, same situation on the other side. The rocker panels and floorboards seem ok, but as you go under the car, there's rot in the whole corner on both sides just behind the wheelwells. This isn't turning out to be such a good car after all. I'll probably end up getting my money back out of it and move on.
Kevin in Hillsboro, Oregon
1977 240D 315Kmi, Liesel the rusty Diesel 


--  My fleet of cars http://www.ebay.com/motors/garage/pub/vehicle/1277784/1985-Mercedes-Benz-300D http://www.ebay.com/motors/garage/pub/vehicle/1276498/2005-Chevrolet-Silverado+3500 http://www.ebay.com/motors/garage/pub/vehicle/1277559/2001-Hyundai-Accent http://www.ebay.com/motors/garage/pub/vehicle/1278047/2001-Kia-Sportage http://www.ebay.com/motors/garage/pub/vehicle/1278117/1997-Chevrolet-C3500

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Re: Now air bubbles coming from tank!

Yeah, and if the vent is plugged the vacuum created could prevent fuel flow to the IP. Might leave the cap cracked and try driving it around?

MIT


On 2/29/2012 9:00 PM, Trish Dougherty wrote:
 

Vent?  Ah, Kevin says yes, when he opens the fuel tank he hears a whoosh.  Yes, we just put $50 in the tank!

On Wed, Feb 29, 2012 at 5:00 PM, Lawrence Rhodes <primobassoon@sbcglobal.net> wrote:
 

If there is a big whoosh when you open the fuel tank your vent is clogged. This
will suck air eventually. Are you sure you have fuel in the tank? Take the
fuel cap off and try priming until no more bubbles. Lawrence Rhodes....




--
Trish Dougherty
PurrFect Harmony Farm
Ennis, TX
http:/purrfectharmonyfarm.intuitwebsites.com


--
No comments:

Re: [diesel_mercedes] Re: Now air bubbles coming from tank!

 

I would assume we got air in there when he blew the line out.  No he hasn't cracked the injectors...will do tomorrow. He used the hand pump to fill up the clear filter after he blew it out. 

Thanks everyone...more good ideas.  We'll be trying them out at some point tomorrow.

On Wed, Feb 29, 2012 at 5:21 PM, Stan George <ssgkag@frontier.com> wrote:
 

You might have introduced air when you blew the filter clean and not got
all of it out. Have you cracked each injector line and pumped the
primer until there are no more bubbles. Assume you did this with the
primary fuel filter also.
--
Stan George Portland <<




--
Trish Dougherty
PurrFect Harmony Farm
Ennis, TX
http:/purrfectharmonyfarm.intuitwebsites.com

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Re: Now air bubbles coming from tank!

 

Vent?  Ah, Kevin says yes, when he opens the fuel tank he hears a whoosh.  Yes, we just put $50 in the tank!

On Wed, Feb 29, 2012 at 5:00 PM, Lawrence Rhodes <primobassoon@sbcglobal.net> wrote:
 

If there is a big whoosh when you open the fuel tank your vent is clogged. This
will suck air eventually. Are you sure you have fuel in the tank? Take the
fuel cap off and try priming until no more bubbles. Lawrence Rhodes....




--
Trish Dougherty
PurrFect Harmony Farm
Ennis, TX
http:/purrfectharmonyfarm.intuitwebsites.com

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] 240D Update

 

I found some things that were better than expected, and a couple things that were a bit worse. The sway bar link isn't broken. The dragging sound was the exhaust pipe rubbing on the axle. As a temporary repair, I replaced the missing donut with a couple zip ties until I get the parts. The bad part was when I jacked up the left front to switch out the badly worn tire with the much better spare. This was when I found a bit of rot under the jack point, same situation on the other side. The rocker panels and floorboards seem ok, but as you go under the car, there's rot in the whole corner on both sides just behind the wheelwells. This isn't turning out to be such a good car after all. I'll probably end up getting my money back out of it and move on.
Kevin in Hillsboro, Oregon
1977 240D 315Kmi, Liesel the rusty Diesel

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Re: Now air bubbles coming from tank!

 

You might have introduced air when you blew the filter clean and not got
all of it out. Have you cracked each injector line and pumped the
primer until there are no more bubbles. Assume you did this with the
primary fuel filter also.
--
Stan George Portland <<

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] Re: Now air bubbles coming from tank!

 

If there is a big whoosh when you open the fuel tank your vent is clogged. This
will suck air eventually. Are you sure you have fuel in the tank? Take the
fuel cap off and try priming until no more bubbles. Lawrence Rhodes....

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] Re: Car wont shift into park

 

plasticy bushings? I'm having a flashback....

"Picture yourself on a train in a station,
With plasticine porters with looking glass ties.
Suddenly someone is there at the turnstile,
The girl with kaleidoscope eyes."

Ok I'm back.

Chuck

--- In diesel_mercedes@yahoogroups.com, BStromsoe <bstromsoe@...> wrote:
>
> It could well be. There are several rubber or neoprene parts down there that are fragile after 30 years. If you have the luxury of 2 or 3 cars, you may want to put yours on safe blocks and check things out as you may want to take advantage to put new plasticy bushings in several areas.
>
>  
> brian from laverne, ca
> Mary (195K)  Martha (280K)
> 1983 w123 300d's
>
>
> ________________________________
> From: Kevlog6 <kevlog6@...>
> To: diesel_mercedes@yahoogroups.com
> Sent: Wednesday, February 29, 2012 1:30 PM
> Subject: [diesel_mercedes] Re: Car wont shift into park
>
>
>  
> Do u think this is the issue?
>
> Mercedessource.com/node/1276
> ??
>
> --- In diesel_mercedes@yahoogroups.com, BStromsoe <bstromsoe@> wrote:
> >
> > I'm going to tear into mine in a week or two - same issue. Stay tuned.
> >
> >  
> > brian from laverne, ca
> > Mary (195K)  Martha (280K)
> > 1983 w123 300d's
> >
> >
> > ________________________________
> > From: Kevlog6 <kevlog6@>
> > To: diesel_mercedes@yahoogroups.com
> > Sent: Wednesday, February 29, 2012 12:59 PM
> > Subject: [diesel_mercedes] Car wont shift into park
> >
> >
> >  
> > I have a 84 300d which has not been going into park for quite a while, i have to move it to neutral to start it, otherwise it drives great.
> > Any idea what this is? Is it the bushing or possibly the parking pawl? I brought it to aamco and they were useless. Thanks all for your help
> >
>

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Re: Car wont shift into park

 

It could well be. There are several rubber or neoprene parts down there that are fragile after 30 years. If you have the luxury of 2 or 3 cars, you may want to put yours on safe blocks and check things out as you may want to take advantage to put new plasticy bushings in several areas.
 
brian from laverne, ca
Mary (195K)  Martha (280K)
1983 w123 300d's
From: Kevlog6 <kevlog6@yahoo.com>
To: diesel_mercedes@yahoogroups.com
Sent: Wednesday, February 29, 2012 1:30 PM
Subject: [diesel_mercedes] Re: Car wont shift into park

 
Do u think this is the issue?

Mercedessource.com/node/1276
??

--- In diesel_mercedes@yahoogroups.com, BStromsoe <bstromsoe@...> wrote:
>
> I'm going to tear into mine in a week or two - same issue. Stay tuned.
>
>  
> brian from laverne, ca
> Mary (195K)  Martha (280K)
> 1983 w123 300d's
>
>
> ________________________________
> From: Kevlog6 <kevlog6@...>
> To: diesel_mercedes@yahoogroups.com
> Sent: Wednesday, February 29, 2012 12:59 PM
> Subject: [diesel_mercedes] Car wont shift into park
>
>
>  
> I have a 84 300d which has not been going into park for quite a while, i have to move it to neutral to start it, otherwise it drives great.
> Any idea what this is? Is it the bushing or possibly the parking pawl? I brought it to aamco and they were useless. Thanks all for your help
>



__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] Re: Car wont shift into park

 

Do u think this is the issue?

Mercedessource.com/node/1276
??

--- In diesel_mercedes@yahoogroups.com, BStromsoe <bstromsoe@...> wrote:
>
> I'm going to tear into mine in a week or two - same issue. Stay tuned.
>
>  
> brian from laverne, ca
> Mary (195K)  Martha (280K)
> 1983 w123 300d's
>
>
> ________________________________
> From: Kevlog6 <kevlog6@...>
> To: diesel_mercedes@yahoogroups.com
> Sent: Wednesday, February 29, 2012 12:59 PM
> Subject: [diesel_mercedes] Car wont shift into park
>
>
>  
> I have a 84 300d which has not been going into park for quite a while, i have to move it to neutral to start it, otherwise it drives great.
> Any idea what this is? Is it the bushing or possibly the parking pawl? I brought it to aamco and they were useless. Thanks all for your help
>

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Car wont shift into park

 

I'm going to tear into mine in a week or two - same issue. Stay tuned.
 
brian from laverne, ca
Mary (195K)  Martha (280K)
1983 w123 300d's
From: Kevlog6 <kevlog6@yahoo.com>
To: diesel_mercedes@yahoogroups.com
Sent: Wednesday, February 29, 2012 12:59 PM
Subject: [diesel_mercedes] Car wont shift into park

 
I have a 84 300d which has not been going into park for quite a while, i have to move it to neutral to start it, otherwise it drives great.
Any idea what this is? Is it the bushing or possibly the parking pawl? I brought it to aamco and they were useless. Thanks all for your help



__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] Car wont shift into park

 

I have a 84 300d which has not been going into park for quite a while, i have to move it to neutral to start it, otherwise it drives great.
Any idea what this is? Is it the bushing or possibly the parking pawl? I brought it to aamco and they were useless. Thanks all for your help

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Now air bubbles coming from tank!

 

Thanks.  I'll tell him. At least we have the old motor to take lines from...not that they are in any better shape.

On Wed, Feb 29, 2012 at 1:48 AM, Bobby Yates Emory <liberty1@gmail.com> wrote:
Trish,  When Kevin blew on the line, there may have been a tiny weak
spot and he blew it out.  The injection pump has a suction pump in it,
also.  It is sucking on the tube going to the fuel tank.  If there is
a tiny leak anywhere, the suction pump will suck in air.  Ask Kevin to
double check the clamp he took off to blow out the line.  It is old
and may not be clamping properly.  Tracking down these air leaks is
difficult -  Good luck.  Bobby

On 2/29/12, Kevin Kraly <kraly@comcast.net> wrote:
> Does the primer pump leak?  Are there any loose connections or weaping fuel
> hoses?  How is the fuel tank vent?  I know, probably more questions than
> answers.  Diesels don't like air in  the lines!
>
> Kevin in Hillsboro, Oregon
> 1977 240D 315Kmi, Liesel the Diesel who will be getting a new primer pump
> soon


--
Toward freedom,

Bobby Yates Emory


------------------------------------

Yahoo! Groups Links

<*> To visit your group on the web, go to:
   http://groups.yahoo.com/group/diesel_mercedes/

<*> Your email settings:
   Individual Email | Traditional

<*> To change settings online go to:
   http://groups.yahoo.com/group/diesel_mercedes/join
   (Yahoo! ID required)

<*> To change settings via email:
   diesel_mercedes-digest@yahoogroups.com
   diesel_mercedes-fullfeatured@yahoogroups.com

<*> To unsubscribe from this group, send an email to:
   diesel_mercedes-unsubscribe@yahoogroups.com

<*> Your use of Yahoo! Groups is subject to:
   http://docs.yahoo.com/info/terms/




--
Trish Dougherty
PurrFect Harmony Farm
Ennis, TX
http:/purrfectharmonyfarm.intuitwebsites.com

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Now air bubbles coming from tank!

 

He replaced the primer pump last weekend since the old one did leak.  He can't see any leaks...not sure about weeping.  Ah, vented??? We haven't touched it so???

On Wed, Feb 29, 2012 at 12:23 AM, Kevin Kraly <kraly@comcast.net> wrote:
 

Does the primer pump leak?  Are there any loose connections or weaping fuel hoses?  How is the fuel tank vent?  I know, probably more questions than answers.  Diesels don't like air in  the lines!
 
Kevin in Hillsboro, Oregon
1977 240D 315Kmi, Liesel the Diesel who will be getting a new primer pump soon




--
Trish Dougherty
PurrFect Harmony Farm
Ennis, TX
http:/purrfectharmonyfarm.intuitwebsites.com

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

Re: [diesel_mercedes] Now air bubbles coming from tank!

Trish, When Kevin blew on the line, there may have been a tiny weak
spot and he blew it out. The injection pump has a suction pump in it,
also. It is sucking on the tube going to the fuel tank. If there is
a tiny leak anywhere, the suction pump will suck in air. Ask Kevin to
double check the clamp he took off to blow out the line. It is old
and may not be clamping properly. Tracking down these air leaks is
difficult - Good luck. Bobby

On 2/29/12, Kevin Kraly <kraly@comcast.net> wrote:
> Does the primer pump leak? Are there any loose connections or weaping fuel
> hoses? How is the fuel tank vent? I know, probably more questions than
> answers. Diesels don't like air in the lines!
>
> Kevin in Hillsboro, Oregon
> 1977 240D 315Kmi, Liesel the Diesel who will be getting a new primer pump
> soon


--
Toward freedom,

Bobby Yates Emory


------------------------------------

Yahoo! Groups Links

<*> To visit your group on the web, go to:
http://groups.yahoo.com/group/diesel_mercedes/

<*> Your email settings:
Individual Email | Traditional

<*> To change settings online go to:
http://groups.yahoo.com/group/diesel_mercedes/join
(Yahoo! ID required)

<*> To change settings via email:
diesel_mercedes-digest@yahoogroups.com
diesel_mercedes-fullfeatured@yahoogroups.com

<*> To unsubscribe from this group, send an email to:
diesel_mercedes-unsubscribe@yahoogroups.com

<*> Your use of Yahoo! Groups is subject to:
http://docs.yahoo.com/info/terms/

No comments:

Re: [diesel_mercedes] Now air bubbles coming from tank!

 

Does the primer pump leak?  Are there any loose connections or weaping fuel hoses?  How is the fuel tank vent?  I know, probably more questions than answers.  Diesels don't like air in  the lines!
 
Kevin in Hillsboro, Oregon
1977 240D 315Kmi, Liesel the Diesel who will be getting a new primer pump soon

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] Now air bubbles coming from tank!

 

WHAT THE HECK???? 

Kevin blew on the line to hopefully clear the crud off of the filter in the tank.  He got fuel into the clear filter, got the car running, then it conked out.  Now he's seeing air bubbles in the clear filter!  He's actually seen them come up from the tank.

Help.... :(

At this point I'm hoping the shop burns down with the car in it.

--
Trish Dougherty
PurrFect Harmony Farm
Ennis, TX
http:/purrfectharmonyfarm.intuitwebsites.com

__._,_.___
Recent Activity:
.

__,_._,___
No comments:

[diesel_mercedes] RE : RockAuto Discount Reminder

 


If you've not yet tried this place , DO SO ! .

new or old, they have it all and usually at very good prices , this discount makes it like free shipping to your door .

-Nate
     --- On Mon, 2/27/12, RockAuto Customer Service <service@rockauto.com> wrote:

From: RockAuto Customer Service <service@rockauto.com>
Subject: RockAuto Discount Reminder
To: VWNate1@yahoo.com
Date: Monday, February 27, 2012, 8:57 AM

RockAuto Discount Reminder

RockAuto Discount Reminder!


Your RockAuto discount code 80111936210637 will expire on March 4, 2012.

If you or anyone you know is thinking of doing some vehicle repair, now's the time to order the parts!

Taking advantage of this discount opportunity is easy! Simply enter your code in the "How did you hear about us" line of the shopping cart. If you are using our traditional HTML catalog, please click the "Apply" button to the right of the field. Your discount will automatically appear, subtracted from your order total. Orders using discount codes must be placed online. Phone orders are not eligible for discounts.

RockAuto carries a full line of mechanical parts, from small items like filters and wiper blades to complete remanufactured transmissions and engine long blocks. We also have a growing number of body parts: door handles, mirrors, sheet metal, bumper covers, even carpets! Our online catalog includes vehicles from 1945 to today, making it easy to find parts no matter what you drive.

Thanks again for buying your auto parts at RockAuto!

Tom Taylor
VP Marketing

www.RockAuto.com
service@rockauto.com
1-866-ROCKAUTO (1-866-762-5288)
(608) 661-1376
Fax: (608) 819-6350


RockAuto uses Customer Lobby to measure our performance. Please take a moment to complete a short survey:

Click to Review RockAuto.com at Customer Lobby

We don't share your email address with anyone, and we try not to bother you with too much email. But if you don't want to hear from us again, please click the link below to unsubscribe.
http://www.rockauto.com/emaillist/emailunsub.php?step=remove&email=VWNate1@yahoo.com

For more information about the car featured at the top of this page, please read the RockAuto newsletter at http://www.rockauto.com/Newsletter .

__._,_.___
Recent Activity:
.

__,_._,___
No comments:
Subscribe to: Posts (Atom)