OOPS ! Kilma II doesn't have an Evil Servo..... sorry ben .
I'd take the blower out or maybe a spare one and take it apart , see if NAPA has the brushes in stock or buy them for 3 X the $ from Kent @ Mercedes' Source . I did this and the instruction booklet was missing a page .
In any case , it's a couple hour job , a spare set of hands is helpful but not mandatory .
If the blower only runs on " high " or occasionally after a bump , the brushes are shot .
-Nate
Ben wrote :
Thanks for the intel everyone. I'll dig into it this weekend and report back. Luckily I have a few parts cars around! J
Ben near Detroit
From: diesel_mercedes@yahoogroups.com [mailto:diesel_mercedes@yahoogroups.com]
Sent: Sunday, November 09, 2014 11:56 PM
To: diesel_mercedes@yahoogroups.com
Subject: [diesel_mercedes] Re: Klima II woes
Brushes in the blower motor is the first thing to check .
New blowers are now very cheap ~ $100 +/- .
I assume you've done the basic Evil Klima I servo testing ? it _MUST_ travel from one extreme to the other evenly and stop with a thump .
if it groans to a stop at one extreme or the other , it _WILL_ burn up your amplifier ~ it's right behind the glove box liner .
-Nate
Ben wrote :
Mark/Nate, need your expertise. The blower on my 79SD stopped blowin. Fuse is fine. Winter's a comin and need heat and defrost. Where to start? Most likely culprit?
Thanks!
Ben near Detroit
Posted by: vwnate1@yahoo.com
| Reply via web post | • | Reply to sender | • | Reply to group | • | Start a New Topic | • | Messages in this topic (7) |
No comments:
Post a Comment